Web Sling Inspection Sling Repair Services Sling Replacement Liftођ Web slings are a type of synthetic lifting sling that are typically made from either nylon or polyester webbing material. synthetic web slings are some of the most common pieces of rigging equipment that you’ll find at any job site because they’re strong enough to support heavy loads, yet are extremely versatile and can be used effectively for a variety of different applications. Never place stich patterns on web slings around sharp corners, hooks, or choker bearing points. never run or drive a vehicle or any other equipment over slings. don’t walk over or stand on slings. 3. conduct thorough web sling inspection. regular sling inspection and its documentation are quite essential.
Sling Inspection Checklist Hse Documents Check for the following: tears and cuts: inspect the entire length of the sling for any signs of tears, cuts, or abrasions. even minor damage can compromise the sling's integrity, leading to catastrophic failures during lifting. frayed edges: pay close attention to the edges of the webbing sling. if you notice frayed or unraveling fibers, the. The web sling and tie down association defines the initial level of inspection as, “before any new or repaired sling is placed in service, it shall be inspected by a qualified person to ensure that the correct sling is being used, as well as to determine that the sling meets the applicable requirements”. Heat and chemical damage can look similar and they both have the efect of damaging sling fibers and compromising the sling's strength. look for discoloration and or fibers that have been fused together and often feel hard or crunchy. to prevent: never use nylon or polyester slings where they can be exposed to temperatures in excess of 200°f. 909.469 2251 4 lift it slings removal from service criteria web slings dol osha 29 cfr 1910.184 and guidance on safe sling use asme b30.9 removal from service criteria web sling and tie down association removal from service criteria synthetic web sling safety bulletin (wssb 1) 2010 make a thorough inspection of slings and attachments.
Comments are closed.